View Single Post
Old 10th September 2019, 05:28 AM   #104
Jim McDougall
Research Consultant
 
Jim McDougall's Avatar
 
Join Date: Dec 2004
Location: Route 66
Posts: 7,658
Default

Quote:
Originally Posted by yulzari
The risk in using small arms powder in artillery is that the smaller grains cause a more rapid burn which gives a higher pressure and the cannon barrel may fail. If it does hold together (for a while at least) then the cannon ball will be projected faster rather than slower so it does not match the reported behaviour of Mexican artillery.

BTW the powder cannot be transported in it's constituents for mixing when needed. That would give you, at best, very bad firework powder. The incorporation of them needs much time and pressure. To get past transport shaking the constituents parts apart corning was developed generations before this war. The powder being pressed under high pressure into solid cakes which are then broken up and sorted through sieves into solid grains which will not break up if well made. It burns better than the earlier powdery 'meal' as the flash can pass through the interstices between the grains. I will spare you issues about adiabatic heating etc. By this time meal is only made for fireworks, rockets and some blasting purposes. Never for firearms but it would match the observed performances of Mexican powder.

I conclude it was probably made as badly made powder, badly corned, badly packaged, roughly transported and badly stored. Based upon low quality firework powder and deteriorated since making. Soft corning and poor incorporation will result in friable grains which will crumble in transport and be more hygroscopic in storage. I do doubt that even the most venal buyer and military would expect to get away with buying actual meal firework powder.


An absolutely brilliant synopsis Yulzari!! thank you so much.
I think your conclusion perfectly sums up the Mexican powder situation and well illustrates the circumstances that were faced with powder production in wider scope of these times.
Very much appreciated.
Jim McDougall is offline   Reply With Quote